Fuse box diagram (fuse layout), location, and assignment the fuses and also relays Lincoln Aviator (UN152) (2002, 2003, 2004, 2005).

You are watching: 2005 lincoln aviator fuse box diagram


*


Checking and Replacing Fuses

Fuses and circuit breakers safeguard your vehicle’s electric system indigenous overloading. If electrical components in the automobile are not working, a fuse may have blown. Inspect the proper fuses prior to replacing any type of electrical components.

Look very closely at the fuse – a broken wire within the fuse identifies blown fuses. If you room not sure or if the is also dark come see, shot replacing the suspected fuse with among the same value that you understand is good.

In situation if you do not have actually a preventive fuse, in one emergency you can pull the end fuses, which might be dispensable for typical driving (for example, audio system, cigarette lighter, OBD, chair heater, and also the like), and use it if that is amperage rating is the same.


Notice

Always switch off the ignition system and also the affected electrical circuit before replacing a fuse.Always disconnect the battery before servicing high present fuses.Never usage a fuse that a higher amperage rating than that indicated, or use any type of other object in location of a fuse, even as a short-term fix. This can reason extensive damage or even fire.If the changed fuses blows again – contact a qualified and also equipped service center.

Passenger Compartment Fuse Box

The fuse dashboard is located listed below the instrument dashboard on the driver’s side.

*

*

№ACircuits Protected
130Moonroof motor, Driver chair switch, Driver chair lumbar
210VAPS module, memory seat module, Body security module, Tire press Monitor system (TPMS), SecuriLock_x0003_ LED, Sunload/Autolamp sensor (SecuriLock_x0001_ LED (2004))
320Radio, navigating module
45Front wiper module
515Flasher relay (turn/hazards)
65Electronic concealed Antenna Module (EHAM) (antenna amplifier), Radio, Moonroof motor, Driver window motor, navigating module and microphone
715Heated mirrors, DEATC module
85Daytime running Lamps (DRL) module, heated PCV valve (2004-2005)
910Back-up lamps (DTRS), Electrochromatic mirror (2004-2005)
1010Heated backlight relay coil, Climate chair modules, assistant A/C temperature blend/mode actuator, A/C clutch relay contact
1120Not used
1215Restraints module
1310Brake change interlock
1452003: Cornering lamps
155Instrument cluster, rear wiper module, Tire pressure Monitor mechanism (TPMS)
16152003: Cigar lighter, OBD II, Liftgate release relay coil and contacts
2005: OBD II
202004: Cigar lighter, OBD II
1715Delayed accessory relay coil, Battery saver relay coil and contact
185Not used
1915Washer pump
205Shifter, Clock, power mirror switch, DVD
2110Brake press switch (ABS), IVD move (2003-2004), RSC switch (2005), Flasher relay
2210ABS/RSC module
237.52004-2005: Liftgate release relay coil and contact
52003: Sunload/Autolamp sensor (SecuriLock_x0001_ transceiver LED)
24302004-2005: Subwoofer, navigation amp
202003: Subwoofer, Navigation
255Trailer tow battery charge relay coil, puddle lamp relay coil (2003)
265SecuriLock_x0003_ transceiver
275Rear park assist, VAPS module
285Radio, Navigation
2910DTRS, feed to Fuse 28
305Instrument cluster, Compass module, assistant A/C relay coil

Advertisements


Relay Box

The relays are situated on the reverse side that the passenger compartment fuse panel. To access the relays, you need to remove the fuse panel.

*

№Relay
1Flasher relay
2Heated backlight relay
3Delayed accessory relay
4Not used
5Battery saver relay
6Not used
7Not used

Engine Compartment Fuse crate Diagram

The power circulation box is situated in the engine compartment. The power distribution box contains high-current fuses that defend your vehicle’s main electrical systems native overloads.

*

№ACircuits Protected
160Power Junction box (PJB)
230Door locks (BSM)
3202005: Cigar lighter
440Heated backlight/mirrors
540Anti-lock Brake system (ABS)/Roll Stability regulate (RSC) module (pump)
660Delayed accessory
720Daytime running Lamps (DRL) module
820Electric cooling fan
920Headlamp switch
1030ABS/RSC module (valves)
1140PTEC relay contacts
1250Ignition/Starter relay
1340Trailer tow relays
1415Brake desk lamp feed
1510Keep alive strength (PTEC/cluster/DEATC), Courtesy lamp (2005)
1620Power point #3
1720Rear wiper module
18204x4 module
1930Driver window motor
2030Electric trailer brake module
2130Memory seat module
2220Main exterior lamps (low beam headlamps, high beam headlamps, fog lamps)
2330Ignition switch
2420Horn relay
2520Power suggest #1
2620Fuel pump relay contacts
2720Trailer tow relays
2820Power point #2
2960Power Junction crate (PJB)
3030Front wiper module
3130Climate-controlled seat modules
3230Passenger chair switch
3330Auxiliary blower motor
3420Right HID relay
3520Left HID relay
3640Blower motor
3715A/C clutch relay, TXV, Transmission, speed control
3815HEGO, VMV, Canister vent, IMCC-LSRC, EGR module, heated PCV (2003)
3915Injectors, Idle air control (2005)
4015PTEC, mass Air circulation (MAF) sensor, Fuel pump relay
4125Coil ~ above plug, PTEC diode/relay
4210Right low beam (halogen)
4310Left low beam (halogen)
4422004-2005: Heated PCV valve (w/DRL only)
152003: Fog desk lamp relay
4522003-2004: Brake press Switch
4620High beams, Fog lamps (2004-2005)
6230Circuit Breaker: Power windows, Moonroof, Audio (delayed accessory)
Relay
47Horn relay
48Fuel pump relay
49High beam relay
50Fog desk lamp relay
51Not used
52A/C clutch relay
53Trailer tow appropriate turn relay
54Trailer tow left turn relay
55Blower engine relay
56Starter relay
57PTEC relay
58Ignition relay
592003-2004: Driver brake applied relay
Diode
60PCM diode
61A/C clutch diode

Auxiliary relay box

The relay box is situated on the front right fender fine underneath the speed control module.

See more: How Old Was Charlie Rich When He Died, Country Legend, Charlie Rich Dies

*

*

№Relay
1Left HID relay
2Right HID relay
3Not used
4EDF relay

Rear Relay Box

The relay crate is located on the behind passenger side 4 minutes 1 trim panel. See your dealer or a certified technician for organization of this relay box.

*

№Relay
1Liftgate release solenoid
2Not used
3Not used
4Trailer tow back-up lamps
5Not used
6Not used
7Trailer tow battery charge
8Trailer tow park lamps
9Not used
102003: Puddle lamps
Diode
11Not used
12Not used